Emerging technologies helping seaports stay green

The technology, called the EcoCrane, is on the U.S. EPA’s list of emerging technologies aimed at advancing clean diesel technology and expertise.
By Patrick Burnson, Executive Editor
August 04, 2010 - LM Editorial

The Port of Los Angeles has been awarded a $731,000 grant from the U.S. Environmental Protection Agency (U.S. EPA) to purchase and test new technology that could significantly reduce diesel emissions and greenhouse gases from rubber tired gantry cranes, which are used for stacking containers.

The technology, called the EcoCrane, is on the U.S. EPA’s list of emerging technologies aimed at advancing clean diesel technology and expertise.

The EcoCrane technology involves replacing a conventional 685-horsepower diesel engine on a rubber tired gantry crane with a downsized 105-horsepower diesel engine that charges a battery pack.  The battery pack drives an electric motor that powers the gantry operation.  Because the engine runs only periodically to maintain the battery charge, the EcoCrane can reduce particulate matter (PM) up to 85 percent and greenhouse gases up to 70 percent.

The Port of Los Angeles is partnering on the project with West Basin Container Terminal at the Port, as well as Ports America, the largest terminal operator and stevedore company in the Americas.
Produced by EcoPower Hybrid Systems, the EcoCrane will be tested over the next 12 months by Ports America at the West Basin Container Terminal to verify the projected emission reductions by the U.S. EPA.  If the test is a success, the Port will consider requiring the EcoCrane technology when future terminal leases are renewed. 

The grant was awarded under the U.S. EPA’s emerging technologies program to promote diesel emission reductions.  The program focuses on advancing new, cutting-edge technologies not yet certified by the U.S. EPA, but that show promise and warrant further evaluation.



About the Author

image
Patrick Burnson
Executive Editor

Patrick Burnson is executive editor for Logistics Management and Supply Chain Management Review magazines and web sites. Patrick is a widely-published writer and editor who has spent most of his career covering international trade, global logistics, and supply chain management. He lives and works in San Francisco, providing readers with a Pacific Rim perspective on industry trends and forecasts. You can reach him directly at .(JavaScript must be enabled to view this email address).


Subscribe to Logistics Management magazine

Subscribe today. It's FREE!
Get timely insider information that you can use to better manage your
entire logistics operation.
Start your FREE subscription today!

Recent Entries

A couple of years ago, the rush to alternatively fueled vehicles was on. Diesel prices had surged past $4, the American Trucking Associations hosted an overflow crowd at its alternative fuels “summit” for trucking executives and energy tycoon T. Boone Pickens offered what might have been the ultimate assessment of where fuel prices were headed.

As a sector with myriad moving parts, coupled with obstacles like increased risks, cost pressures, among others, the healthcare supply chain is replete with uncertainties. But there are ways for the sector to counter these challenges, too, according to the seventh annual UPS “Pain in the (Supply) Chain healthcare surve

The study examines the trajectory of offshoring cost arbitrage to low-cost developing countries, the rise of new locations, and the fact that there’s ample room for growth.

In a rare show of solidarity, various trucking interests are asking the Department of Transportation’s Federal Motor Carrier Safety Administration to remove online safety ratings of individual motor carriers until flaws in the CSA methodology are fixed.

While it feels somewhat hard to fathom, the stage is set for the Council of Supply Chain Management Professionals (CSCMP) Annual Conference in San Antonio, Texas.

Article Topics

News · Technology · Green · Container · All topics

About the Author

Patrick Burnson, Executive Editor
Patrick Burnson is executive editor for Logistics Management and Supply Chain Management Review. Patrick covers international trade, global logistics, and supply chain management. He lives and works in San Francisco, providing readers with a Pacific Rim perspective on industry trends and forecasts. Contact Patrick Burnson

Comments

Post a comment
Commenting is not available in this channel entry.


© Copyright 2013 Peerless Media LLC, a division of EH Publishing, Inc • 111 Speen Street, Ste 200, Framingham, MA 01701 USA